[SEAT] [Leon 1P] verwarming / airco bediening is defect

Ddutchman

New member
Lid geworden
14 apr 2022
Berichten
6
De verwarming/airco bediening van mijn Seat Leon uit 2010 werkt niet meer. Hij gaat niet meer aan en de ledjes branden ook niet. De radio en de stuurbediening werken wel. Als ik de auto start is er geen enkele reactie als ik op de knoppen druk of draai. Ik hoor dat de 2 fans onder de motorkap op volle kracht draaien. Ik heb m.b.v. een imitatiekabel de auto uitgelezen maar mij wordt niet duidelijk waar het mis gaat. Ik heb alle zekeringen gecontroleerd. Zodra ik de auto uitzet hoor ik onder de motorkap een hoop getik. Het lijkt op een relais dat sluit/opent.
Dit is de output van VCDS:
--------------------------------------------------------------------------
Chassis Type: 1P-SE35 (1K0)
Scan: 01 03 08 09 15 16 17 19 25 2E 42 44 46 52 56 62 72
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: Cannot be reached 1100
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: Malfunction 0010
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: Malfunction 0010
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000

-------------------------------------------------------------------------------
Address 01: Engine Labels: 03C-906-022-CAX.clb
Part No: 03C 906 022 AQ
Component: MED17
Shop #: WSC 06402 785 00200
VCID: 6BD572AB4A85F9D306-FFFE

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: None
VCID: 55A13453BC015F23C0-FFFE

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 08: Auto HVAC
Cannot be reached

-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels:. 1K0-937-08x-09.clb
Part No SW: 5K0 937 086 C HW: 5K0 937 086 C
Component: BCM PQ35 M 011 0029
Shop #: WSC 04941 000 00000
VCID: 3467A9D7973B662B17-FFFE


-------------------------------------------------------------------------------
Address 15: Airbags Labels: None
VCID: 55A13453BC015F23C0-FFFE

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: None
VCID: 55A13453BC015F23C0-FFFE

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:* None-SRI1
Part No SW: 1P0 HW: 1P0 920 810 H
Component: KOMBI H07 0308
Serial number: 00000000000000
Coding: 110A00
Shop #: WSC 99999 1023 2097151
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04052
ROD: EV_Kombi_UDS_VDD_RM09_SE35.rod
VCID: 3169A0C3602953037C-8064

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530-V4.clb
Part No SW: 1K0 907 530 AD HW: 1K0 907 951
Component: J533 Gateway H16 0233
Coding: E9807F06000212000202
Shop #: WSC 06402 785 00200
VCID: 69D908A34079EBC374-803C

Subsystem 1 - Part No: 1K0 907 530 AD
Component: J533 Gateway H16 0233

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:| 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H07 0308
Serial number:
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03005
ROD: EV_Immo_UDS_VDD_RM09_VW32.rod
VCID: 6ADB77AF8D7FE0DB7D-803E

No fault code found.

-------------------------------------------------------------------------------
Address 2E: Media Player 3 Labels: 5N0-035-342.lbl
Part No SW: 5N0 035 342 B HW: 5N0 035 342 B
Component: SG EXT.PLAYER H13 0090
Shop #: WSC 04941 000 00000
VCID: 2643439F51E704BB99-FFFE

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 1T0 959 701 AG HW: 3C0
Component: TUER-SG FT 002 0311
Revision: 12101005 Serial number: 0000620180
Coding: 0010B0
Shop #: WSC 99999 123 12345
ASAM Dataset: EV_DCU42BroseDriveSide A03004
ROD: EV_DCU42BroseDriveSide.rod
VCID: 7CF741F7F7EB6E6B9F-8028

Slave Driver:
Subsystem 1 - Part No SW: 1K0 959 703 AF HW: 1K0 959 795 S Labels: 1K0-959-70X-GEN4.CLB
Component: J388__TSG-HL 006 1401
Serial number: 00000004777096
Coding: 000090

2 Faults Found:
68099 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 133
Mileage: 137915 km
Date: 2127.14.31
Time: 00:30:49

68107 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 18
Reset counter: 102
Mileage: 137267 km
Date: 2127.14.31
Time: 12:34:45


-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 1K0 909 144 J
Component: EPS_ZFLS Kl. 142 3001
Shop #: WSC 06402 785 00200
VCID: 3169A0C3A82953037C-8064

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J38) Labels:. 3C0-959-70X-GEN4.clb
Part No SW: 1T0 959 702 AC HW: 3C0 959 792 A
Component: TUER-SG BT 002
Revision: 14101005 Serial number: 0000457713
Shop #: WSC 12345 123 12345
ASAM Dataset: EV_DCU52BrosePasseSide A03004
ROD: EV_DCU52BrosePasseSide.rod
VCID: 79F958E3F8D95B4384-802C

Slave Passenger:
Component: J389__TSG-HR 1401
Coding: 000090

2 Faults Found:
68099 - Function Restricted due to Missing Message(s)
U1111 00 [000] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 133
Mileage: 137915 km
Date: 2127.14.31
Time: 00:30:49

0000 - ROD - Unknown Error Code
- 00 [000]
Intermittent - Not Confirmed - Tested Since Memory Clear

-------------------------------------------------------------------------------
Address 56: Radio Labels: None
VCID: 55A13453BC015F23C0-FFFE


End-------------------------(Elapsed Time: 29:53)--------------------------
 

RoadRunnerRik

Administrator
Lid geworden
16 jun 2014
Berichten
6.406
Ik zou eerst eens beginnen om alle foutcodes te verwijderen. Pas nog een geintje gehad bij VW Touran met de climate controle. Waslijst aan foutcodes in het systeem, zoveel dat je het niet kon herleiden. Waslijst opgeslagen, alle foutcodes gewist en daarna werkte het systeem weer als nieuw... Ook kwamen er geen nieuwe storingen terug. Had hem al aangegeven, mocht je climate controle er weer mee stoppen, nog een keer uitlezen in de hoop dat je dan minder foutcodes hebt.
 

Tomtomm

Active member
Lid geworden
25 aug 2014
Berichten
129
In de foutcode scan die je stuurt zie je dat de 08 (airco bedieningspaneel) niet reageert.
De module meld zich niet op het netwerk, probeer de unit eens uit te lezen, lukt dit niet controleer dan eens de voedingen en massa’s op de module (airco bedieningspaneel).
Het zou best kunnen zijn dat er een simpele zekering defect is


Verzonden vanaf mijn iPhone met Tapatalk
 

Ddutchman

New member
Lid geworden
14 apr 2022
Berichten
6
Bedankt voor de reacties! Ik ga eerst de tip van RoadRunnerRik proberen. Als dat niet helpt dan zal ik het aircobedieningspaneel moeten zien uit te bouwen en de voedingskabel en massa meten zoals Tomtomm adviseert. Zit daar nog een aparte zekering in het airco bedieningspaneel? Klopt het dat zekering 4 (links naast het stuur) de algemene zekering voor dit paneel is?
 
Laatst bewerkt:

Ddutchman

New member
Lid geworden
14 apr 2022
Berichten
6
Het resetten heeft niet geholpen. Ik heb het airco bedieningspaneel (5P0907044P) uitgebouwd en zonder de sleutel op contact meet ik 12,75V op de voedingskabel en na het starten 13,90V. Ik heb geen idee hoe ik deze module zelf doormeet. OF kan ik al concluderen dat de airco module defect is aangezien er geen ledjes branden en geen enkele knop functioneert? En wat opvalt is het geluid zodra ik de sleutel van contact haal. Een relais?
Mijn richtingaanwijzers knipperen onregelmatig net als het alarmlicht. En de 2 koelfans blazen 100% sinds dit euvel.
 
Laatst bewerkt:

Tomtomm

Active member
Lid geworden
25 aug 2014
Berichten
129
Het geluid wat je hoort in het filmpje is normaal. Je gasklep doet altijd een soort van basic run. Even helemaal open en dicht.

Dat je koelvin volgas draait klopt ook, dit komt omdat de hvac module niet communiceert.
Dat je knippers vreemd doen kan ik niet helemaal verklaren, misschien heb je wel 2 problemen in de wagen..

Zo te zien heb je wel voeding, heb je ook gecontroleerd of de module massa heeft ?
Is dat ook in orde dan kunnen we controleren of de communicatie in orde is (can bus).
Als je je vin stuurt (kan in een privé bericht) kan ik een origineel schema voor je opzoeken[emoji1303]


Verzonden vanaf mijn iPhone met Tapatalk
 

Ddutchman

New member
Lid geworden
14 apr 2022
Berichten
6
Bedankt voor de hulp!
Ik heb via Marktplaats een 2e hands airco bedieningspaneel gekocht en de koelvin werkt weer normaal en al het luchtverkeer in de auto is weer te regelen! Ik ben een stukje gaan rijden en heb vervolgens VCDS V21.3 opnieuw een full scan laten uitvoeren.
Hoe meet ik de massa? Multimeter op ohm en massa kabel en massa aansluiting airco paneel?
Dit is de outpunt van VCDS na het vervangen van 5P0907044P:
--------------------------------------------------------------------------------------------------------
Chassis Type: 1P-SE35 (1K0)
Scan: 01 03 08 09 15 16 17 19 25 2E 42 44 46 52 56 62 72

Mileage: 138470km

01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: Sporadic communication error 1000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: Malfunction 0010
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000

-------------------------------------------------------------------------------
Address 01: Engine Labels: 03C-906-022-CAX.clb
Part No: 03C 906 022 AQ
Component: MED17.5.20 G 6660
Coding: 0000072
Shop #: WSC 06402 785 00200
VCID: 6BD572AB4A85F9D306-FFFE

Subsystem 1 - Part No: 03C 906 022 AQ
Component: MED17.5.20 G 6660

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: None
VCID: 55A13453BC015F23C0-FFFE

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:| 5K0-907-044.clb
Part No SW: 5P0 907 044 P HW: 5P0 907 044 P
Component: Climatronic H15 0702
Revision: 00001001
Coding: 0000000003
Shop #: WSC 06402 785 00200
ASAM Dataset: EV_Climatronic A01006
ROD: EV_ClimaAutoBasis_SE35.rod
VCID: 3D718CF3AC71A763E8-8068

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 1K0-937-08x-09.clb
Part No SW: 5K0 937 086 C HW: 5K0 937 086 C
Component: BCM PQ35 M 011 011 00290029
Shop #: WSC 04941 000 00000
VCID: 3467A9D7973B662B17-FFFE

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 15: Airbags Labels: None
VCID: 55A13453BC015F23C0-FFFE

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY9.lbl
Part No SW: 1K0 953 549 CF HW: 1K0 953 549 CF
Component: J0527 856 0111
Coding: 0000532
Shop #: WSC 06402 785 00200
VCID: 78FF5DE70BD3424BFB-802C

Subsystem 1 - Part No: 1P0 959 538 C Labels: 3C8-959-537.CLB
Component: E221__MFL-TAP H02 0101
Coding: 00000226
Shop #: WSC 00000

Subsystem 2 - Part No: 1K0 953 549 CF
Component: J0527 856 0111

Subsystem 3 - Part No: 1P0 959 538 C
Component: E221__MFL-TAP H02 0101

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5K0-920-xxx-17.clb-SRI1
Part No SW: 1P0 920 810 H HW: 1P0 920 810 H
Component: KOMBI H07 0308
Serial number: 00000000000000
Coding: 110A00
Shop #: WSC 99999 1023 2097151
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04052
ROD: EV_Kombi_UDS_VDD_RM09_SE35.rod
VCID: 2D51BCB37C1137E358-8078
Note: Excessive Comm Errors

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530-V4.clb
Part No: 1K0 907 530 AD
VCID: 69D908A34079EBC374-FFFE

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:| 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H07 0308
Serial number:
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03005
ROD: EV_Immo_UDS_VDD_RM09_VW32.rod
VCID: 6ADB77AF8D7FE0DB7D-803E

No fault code found.

-------------------------------------------------------------------------------
Address 2E: Media Player 3 Labels: 5N0-035-342.lbl
Part No SW: 5N0 035 342 B HW: 5N0 035 342 B
VCID: 2643439F51E704BB99-FFFE

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 1T0 959 701 AG HW: 3C0 959 793 A
Revision: 12101005 Serial number: 0000620180
Coding: 0010B0
ASAM Dataset: EV_DCU42BroseDriveSide A03004
ROD: EV_DCU42BroseDriveSide.rod
VCID: 7CF741F7F7EB6E6B9F-8028

Slave Driver:
Subsystem 1 - Part No SW: 1K0 959 703 AF HW: 1K0 959 795 S Labels: 1K0-959-70X-GEN4.CLB
Component: J38ª 006 1401
Serial number: 0000000477
Coding: 000090

2 Faults Found:
68099 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 50
Mileage: 137915 km
Date: 2022.04.24
Time: 00:30:49

68107 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 30
Reset counter: 69
Mileage: 137216 km
Date: 2000.00.00
Time: 00:00:00


-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 1K0 909 144 J
Component: EPS_Z
Shop #: WSC 06402 785 00200
VCID: 3169A0C3A82953037C-FFFE

No Faults Found
or DTCs not supported by controller
or a communication error occurred

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 1T0 959 702 AC HW: 3C0 959 792 A
Component: TUER-SG BT 002 0311
Revision: 14101005 Serial number: 0000457713
Coding: 0010B0
Shop #: WSC 12345 123 12345
ASAM Dataset: EV_DCU52BrosePasseSide A03004
ROD: EV_DCU52BrosePasseSide.rod
VCID: 79F958E3F8D95B4384-802C

Slave Passenger:
Subsystem 1 - Part No SW: 1K0 959 704 AF HW: 1K0 959 794 S Labels: 1K0-959-70X-GEN4.CLB
Component: J389__TSG-HR 1401
Serial number: 00000004782253

2 Faults Found:
68099 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 50
Mileage: 137915 km
Date: 2022.04.24
Time: 00:30:49

68107 - Function Restricted due to Missing Message(s)
U1111 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 33
Reset counter: 50
Mileage: 137267 km
Date: 2022.04.24
Time: 12:34:45


-------------------------------------------------------------------------------
Address 56: Radio Labels: 5M0-035-1xx-56.clb
Part No SW: 1P0 035 153 B HW: 1P0 035 153 B
Shop #: WSC 04941 000 00000
VCID: 2447599727DBF6AB87-FFFE

No Faults Found
or DTCs not supported by controller
or a communication error occurred

End-------------------------(Elapsed Time: 03:41)--------------------------
 

Tomtomm

Active member
Lid geworden
25 aug 2014
Berichten
129
Dat is goed nieuws!

Massa kun je eigenlijk op dezelfde manier controleren zoals je voeding controleert

Voeding = multimeter op volt en je com aansluiting op massa accu. Je meetaansluiting dan op voeding van het te controleren deel.

Massa = multimeter op volt en je com aansluiting op de plus van accu. Je meetaansluiting dan op massa van het te controleren deel.
Als je hier dan 12/13 volt meer weet je dat je een goede massa hebt.


Verzonden vanaf mijn iPhone met Tapatalk
 

MaXXeR

New member
Lid geworden
11 jan 2017
Berichten
26
Wil even aanvullen, want ik miste 'm ook in vcds en deed uiteraard niets. Bleek dat 1 van de 3 stekkers niet volledig ingeklikt was aan het begin en later zelfs 2 stekkers. In eerste geval deed de display het nog maar reageerde niets meer en met die 2e los was ook de display uit. Stekkers er goed volledig(!) in en er was niets meer aan de hand.
 
Bovenaan